Owner’s Manual Save this manual for future reference. Williams Furnace Co. 250 West Laurel Street Colt
Installing Your Furnace 10 4. Spillage means air starvation and a fresh air duct or air intakes must be installed to provide air directly to the
Installing Your Furnace FOR EXAMPLE: Your furnace is rated at 60000 Btu/hr. The water heater is rated at 30,000 Btu/hr. The total is 90,000 Btu/
Installing Your Furnace 12 WARNING: Remove 4”x14” fiberglass gasket from bottom of header plate and discard. This gasket is not used when the furn
Installing Your Furnace CAUTION: Do not run wire behind flanges of header plate or in any location where it might be damaged. Av
Installing Your Furnace 14 NOTE If you decide to route gas line through right side of furnace, simply remove the knock-out provided in furnace side
Installing Your Furnace ALL MODELS ATTACH HOLD-DOWN PLATE NOTE Header plate should already be attached. Fasten hold-down plate to top of
Installing Your Furnace 16 COMPLETE THE VENTING Refer to Fig. 18. Install oval to round adapter. Complete the piping extending it through the
Installing Your Furnace REMOVE BURNER AND CONTROLS Locate the burner and hex nuts that secure it. Remove the two (2) hex nuts (one from each en
Installing Your Furnace 18 Gas Supply and Piping Gas control valve, within the furnace, is shipped with a seal over gas inlet tapping. Do not
Installing Your Furnace The following rules apply: 1. Use new, properly reamed pipe free from metal chips and debris such as steel or black
Warranty 2 Warranty & Installation Record – 2 The manuf acturer, Williams Furnace Co., warrants this wall f urnace or heater to the original
Installing Your Furnace 20 Thermostat Installation
Installing Your Furnace Optional Accessory Installation SIDE OUTLET MODEL 6701 REAR OUTLET MODEL 6801 SHORT REAR OUTLET MODEL 6802 CAUTION:
Installing Your Furnace 22 MOUNTING Refer to Fig. 29. BEFORE placing the furnace into position, place Out Boot against the furnace casing with i
Installing Your Furnace 2-WAY FRONT DIFFUSING GRILLE KIT MODEL 6703 Refer to Fig. 32. CAUTION: For use only in conjunction with a f
Installing Your Furnace 24 Start-Up Procedure WARNING: Danger of bodily injury or death. Liquefied petroleum L.P. Gas is heavier than
Operating Your Furnace Operating Your Furnace STANDING PILOT MODELS 6008531; 6008532 NOTE: For models equipped with WILLIAMS gas valve P32
Operating Your Furnace 26 FOR YOUR SAFETY, READ BEFORE LIGHTINGWARNING: If you do not follow these instructions exactly, a fire or explosi
Caring for Your Furnace Care – 27 How To Care For Your Furnace WARNING: Danger of bodily injury or death. Turn off electric power supply at
Caring for Your Furnace 28 How To Care For Your Furnace BURNER CLEANING Check burner. If cleaning is required, contact a qualified service techn
Troubleshooting Care – 29 FOR MODELS: 6008532; 6008531 SYMPTOM POSSIBLE CAUSE CORRECTIVE ACTION 1. Pilot w ill not stay lit after follow ing
Contents Your Williams Warranty ...2 Installation Record...
Troubleshooting 30 SYMPTOM POSSIBLE CAUSE CORRECTIVE ACTION 7. Furnace operates but w ill not shut "OFF" w hen room temperature is at
Replacement Parts Accessories– 31 6008531; 6008532 6008531; 6008532 34 & 35
Replacements Parts 32
Replacements Parts List REPLACEMENT PARTS FOR MODELS 6008531; 6008532 Ref. Number Description PART NO. FOR MODEL 6008532 6008531 1 Outer Casing
Replacements Parts List 34 52 Orifice Fitting, Specify Gas Type & Input P090539 P090553 53 Locknut, Special (2 Required) P026200 P026200 54 Ga
Forsaire Hardwire Accessory - 9940 Installation Instructions This Kit is for use with Models: 3508331; 3508332; 3508731; 3508732; 4007331; 40073
Hints and Information 36 Service Hints If your furnace fails to work correctly, you may avoid the inconvenience and cost of a servic
Safety Rules 4 WARNING: Read these rules and the instructions carefully. Failure to follow these rules and instructions could cause a
Introduction Introduction – 5 Please read our instructions before you install and use your furnace. This will help you obtain the full value from
Introduction 6 Optional Accessories SIDE OUTLET REGISTER 6701 Pg. 21 Let’s you route some heated air to a second room. Mounts on side wall of se
Installing Your Furnace The following steps are needed for proper installation and safe operation of your furnace. If you have any doubts
Installing Your Furnace 8 With standard furnace discharge outlet, do not install closer than 4 inches to intersecting wall. Choose a location for
Installing Your Furnace AIR REQUIREMENTS The requirements for providing air for combustion and ventilation are listed in the National Fuel Gas Co
Kommentare zu diesen Handbüchern